vled-40w series dimmable led drivers constant current plastic housing electrical specifcations input voltage range: 100-277 vac nom. (90-305 v min/max) frequency: 50/60 hz nom. (47-63 hz min/max) power factor: >0.90 @ full load, 100v through 277v inrush current: 70 amps max @ 220 vac, cold start 25oc input ac current: 0.6 a max 100vac, 0.3 a max 220vac maximum power: 42w thd: <_ 20% @ full load line regulation: 1% load regulation: 3% leakage current: 0.75 ma max @ 277vac 60hz turn-on delay: 0.6s @ 110vac, 0.3s @ 220vac typical output ripple: 50%, related to the voltage-current curve of the led no-load power dissipation: 6w protection: over-voltage, over-temperature (110o) and short circuit protection with self-recovery environmental specifcations minimum starting temp: -40oc maximum case temp. 90c storage temperature: -40oc to +85oc humidity: 5% to 100% cooling: convection sound rating: class a mtbf: 327,000 hours @ 120vac, 80% load and 25oc ambient conditions per mil-hdbk-217f lifetime: 116,000 hours @ 120vac, 80% load and 60oc ambient emc: fcc 47cfr part 15 class b compliant weight: 350 g constant current - product specifcations model number output current (ma 5%) output voltage range (vdc) max. output power (w) typical effciency vled40w-120-c035 0-xx 350 60-120 42 90% vled40w-094-c045 0-xx 450 47-94 42 89% vled40w-056-c070 0-xx 700 28-56 39 89% vled40w-038-c105 0-xx 1050 20-38 40 88% vled40w-032-c128 0-xx 1280 17-32 42 87% vled40w-030-c140 0-xx 1400 15-30 42 87% vled40w-024-c175 0-xx 1750 12-24 42 87% class 2: us/canada us only e332160 sign components manual ordering options: -d: 0-10v dimmable version comes with an extra three wires +purple/-gray/yellow on the output side. 0-10v dimming is compatible with most quality 0-10v wall dimmers and direct 0-10v analog signal. see page 2 for additional specifcations. -xx indicates dimming options are available. see options at left. blank = fxed current output ? total power: 40 watts ? input voltage: 100-277 vac nom. ? ul dry & damp location rated ? ip66 ? high power factor with active correction ? output protection & lightning protection ? ul8750 and en61347 rev 9-2-15 specifcations subject to change without notice. note: led drivers are designed and intended to operate led loads only. non-led loading may be outside the specifed design limits of our led drivers, and therefore cannot be covered by any warranty. if you desire to use our led drivers to operate non-led loads please contact us to discuss compatibility. thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com
pg 2 of 4 dimensions - mm 2.76 [ 70.0 ] 10.630.79 [ 27020 ] 7.870.79 [ 20020 ] 0.39 [ 10.0 ] 0.39 [ 10.0 ] 0.390.08 [ 10.02 ] 0.14 [ 3.6 ] 0.2 [ 5.0 ] 1.18 [ 30.0 ] 1.18 [ 30.0 ] 1.26 [ 32.0 ] 3.74 [ 95.0 ] 0.390.04 [ 10.01 ] output red (+) black (-) input white (n) black (l) dimming purple (+) gray (-) yellow (vaux) wire specs: ac input: #18awg dc output: #18awg dimming control: #26awg 1.97 [50.0] 1.32 [33.5] tc = 90c max 30 case temperature (c) lifetime (khrs) lifetime / case temperature 0 15 30 45 60 75 90 105 120 135 40 50 60 70 80 35 45 55 65 75 85 90 safety and emc compliance l/cl l8750, l1012, l1310 class 2, csa-c22.2 no. 107.1, csa-c22.2 no. 223-m91 class 2 c e en61347-1, en61347-2-13 c c b19510.14-2009, b19510.1-2009, b17743-2007, b17625.1-2003 fcc part 15 class b ansi c63.4: 2009 en55015 conducted emission test radiated emission test en61000-3-2 harmonic current emissions en61000-3-3 voltage fuctuations & ficker derating curve load (%) 100 80 60 40 20 0 ambient temperature (c) 1 20v a c 2 77v a c -20 -10 0 10 20 30 40 50 60 70 vled40w cc/d series thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com ssl solutions faster than the speed of light ?
pg 3 of 4 dimming control parameters minimum typical maximum 12v output voltage 10.8v 12v 13.2v 12v output source current 0 ma 20ma absolute maximum voltage on the 1-10v input pin 0v 15v source current on 1-10v input pin 0a 200a the dimmer control is operated from an input signal of 1 C 10 vdc. recommended implementation provided below. typical analog 0-10v dimming circuit dim+ (purple) v+ (red) v- (black) vaux (yellow) vac l n 0-10v dimmer dim- (gray) vled40w-xxx-cxxxx-d external resistor circuit dim+ (purple) vaux (yellow) vac l n rx 1k ohm dim- (gray) vled40w-xxx-cxxxx-d external resistor circuit dim+ (purple) vaux (yellow) vac l n 1k ohm rx dim- (gray) vled40w-xxx-cxxxx-d dimming voltage (v) normalized output current normalized output current normalized output current output current / dimming voltage 0% 20% 40% 60% 80% 100% 0 1 2 3 4 5 6 7 9 8 10 rx (k?) output current / rx 0% 20% 40% 60% 80% 100% 0 0.5 1 1.5 2 2.5 3 3.5 4.5 4 5 rx (k?) output current / rx 0% 20% 40% 60% 80% 100% 0 1 2 3 4 5 6 7 9 8 10 11 12 13 14 15 16 note: do not connect dim- to v- vled40w cc/d series thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com ssl solutions faster than the speed of light ?
pg 4 of 4 0 normalized output current pf power factor / output current power factor / output voltage 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1.0 10% 20% 30% 40% 50% 60% 70% 80% 90% 100% 50% normalized output voltage pf 0.70 0.65 0.60 0.75 0.80 0.85 0.90 0.95 1.00 60% 70% 80% 90% 100% power fac t or charac teristi c s (3 50ma model ) effi ciency / load (3 50ma model) 1 20v a c 2 20v a c 2 77v a c 1 20v a c 2 20v a c 2 77v a c 0 normalized output current efficiency efficiency / output current efficiency / output voltage 0 10% 20% 30% 40% 50% 60% 70% 80% 90% 100% 10% 20% 30% 40% 50% 60% 70% 80% 90% 100% 50% normalized output voltage efficiency 66% 71% 76% 81% 86% 91% 96% 60% 70% 80% 90% 100% 1 20v a c 2 20v a c 2 77v a c total harmonic distortion (700ma model) 50% normalized output voltage thd thd / output voltage 0% 5% 10% 15% 20% 25% 60% 70% 80% 90% 100% 1 20v a c 2 20v a c 2 77v a c 1 20v a c 2 20v a c 2 77v a c vled40w cc/d series thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com ssl solutions faster than the speed of light ?
|
